Page 1 - Crown Head Owners Manual L91v0116v

crown head ™

CENTRIFUGAL DISCHARGE SERIES AUTOMATIC MARINE TOILET
INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS
THE FOLLOWING ARE CAUTIONARY STATEMENTS THAT MUST BE READ AND
FOLLOWED DURING BOTH INSTALLATION AND OPERATION.
WARNING: Raritan Engineering Company, Inc. recommends that a qualified person or electrician install this
product. Equipment damage, injury to personnel or death could result from improper instal-
lation. Raritan Engineering Company, Inc. accepts no responsibility or liability for damage to
equipment, injury or death to personnel that may result from improper installation operation of
this product.
WARNING: HAZARD OF SHOCK OR FIRE
Always use recommended fuse, circuit breaker and wire size.
Motors and relays used with this product are “Ignition Protected”. They are not however, ex-
plosion-proof as defined in 46CFR 110.15-65(e), Subchapter J-Electrical Engineering.
DO NOT run this system dry (without water).
DO NOT run continuously for more than 30 seconds.
WARNING: HAZARD OF FLOODING - Always shut off seacock(s) before leaving the boat unattended.
Whenever possible hose connections should be secured using two (2) all-stainless steel hose
clamps. Integrity of clamps, hoses and fittings should be checked periodically.
INTRODUCTION Use only Raritan Cleans Potties as an additive in

The Crown Head is a powerful centrifugal the Concentrate tank. Other products may cause
macerating toilet that thoroughly breaks down damage to the internal parts of the toilet.
waste in preparation for treatment or holding and 2. Using C.P. a bio-enzymatic toilet bowl cleaner
requires little maintenance. It can be ordered with (available from Raritan Engineering) will keep
a 90 degree or a straight discharge fitting, a white the bowl clean and fresh smelling.
marine-size bowl or household-style bowl available Do not use any chemical that contains ammonia,
in either white or almond. ethyl acetate, phosphoric acid or concentrated
OPERATION chlorine bleach as a cleaner. These may cause

CAUTION: The Crown Head motor is designed damage to the toilet.
to be used as a toilet and is not rated for 3. Make a periodic visual check for leaks at the base of
continuous duty. the toilet and at hose connections.

The Crown Head doesn’t require special toilet paper, 4. Check semiannually to ensure all wire terminals and
junctions are corrosion-free.
however, hard objects or stringy substances (paper
towels, feminine hygiene products, filter cigarettes, 5. When boat is not in use, flushing the system with fresh
etc.) must not be thrown into the toilet as they will water will help minimize odors and reduce mineral
cause damage. buildup.
FIG 1 CROWN HEAD - Overall Dimensions
A. Momentary Operation Using Push-button
Switch (#164000BR) - not included: Depress 14 3/8”(36.5)Household-style 20”(50.8cm) Household-style
17”(43.2cm)
13”(33cm)
button and hold. Water should appear in the Marine-size Marine-size
17 3/8”
bowl within one to four seconds. Flush as (44.1cm)
necessary. Household-style Front Side
17”
(43.2cm)
MAINTENANCE Marine-size
1. Refill the reservoir when empty; occasionally (15.9cm) 1/2” (1.3cm)
6 1/4”
check that it has not run dry. 10 7/8” (27.6cm) (approx.) 8 9/16”
(21.9cm)
2”
C.P., Cleans Potties, (1PCP22) helps minimize 11 7/8” (30.2cm) 13 7/8” (34.2cm) (5.1cm)
the need for cleaning. 1
1 L91 0116jlc